Product ID:EZ WELD EZ THREAD SEAL
MSDS Date:01/01/1993
FSC:6850
NIIN:00N066381
MSDS Number: BZRWK

PCI INDUSTRIES INC

1661 OLD DIXIE HIGHWAY
RIVIERA BEACH, FL 33419
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 407-844-0241

Preparer: HARRY AUSTIN

Cage: FO174

PCI INDUSTRIES INC

9845 RIVIERA BEACH, FL 33419 US

Telephone: (407) 844-0241

Cage: FO174

NON-HAZARDOUS INGREDIENTS

OSHA PEL N/K

ACGIH TLV: N/K

ABSORBENT MATL SHOVEL INTO CONTAINERS TO BE

RTECS: 9999999ZZ

TLV(S). EXPLOSION PROOF EQUIPMENT IS ADVISED.

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE CONTACT:CAUSES IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN CONTACT:CAN CAUSE SLIGHT TO
MODERATE IRRITATION & DEFATTING (DRYNESS). INHALATION:CAN CAUSE
NASAL & RESPIRATORY IRRITATION & HEADACHE. INGESTION:CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, DIZZINESS, VOMITING &
DIARRHEA. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:EYE CONTACT:MARKED IRRITATION
(BURN), POSSIBLE TRANSIENT CORNEAL OR CONJUNCTIVAL INJURY. SKIN
CONTACT:SEVERE IRRITATION & DEFATTING. CAN CAUSE A RASH.
INHALATION:CAN CAUSE RESPIRATORY IRRITATION, VOMITING &
INCOORDINATION.INGESTION:CAUSES NAUSEA, VOMITING, HEADACHE,
DIZZINESS, STUPOR, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. CALL
MD. SKIN:REMOVE CONTAM CLTHG PRIOR TO FLUSHING W/WATER. LAUNDER
CONTAM CLTHG BEFORE RE-USE. WASH SKIN THORO W/MILD SOAP & WATER.
INHAL:SEEK F RESH AIR. IF PERSON IS AFFECTED, REMOVETO FRESH AIR.
IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, GIVE ARTF
RESP. KEEP PERS WARM, QUIET & GET MED ATTN. INGEST:DO NOT INDUCE
VOMIT. (SUPDAT)

Flash Point Method:TCC
Flash Point:177F,81C
Lower Limits:1%
Upper Limits:5%
Extinguishing Media:ALCOHOL RESISTANT FOAM, CARBON DIOXIDE OR DRY
CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER
FLAMES, SPKS, HEATER, SMOKING, ELEC MOTORS, STATIC (SUPP DATA)

Spill Release Procedures:EXTING & DO NOT TURN ON ANY IGNIT SOURCE UNTIL
AREA DETERMINED TO FREE FROM EXPLO/FIRE HAZS. SM SPILL:ABSORB
W/EARTH, SAND/SIMILAR INERT MATL & DISP OF W/SOLID WASTE ACCORDING
TO FED, STATE & LOC REGS . FLUSH SPILL AREA W/WATER. LG
SPILL:ERECT(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
AVOID BRTHG VAP. AVOID CONTACT W/EYES, SKIN & CLTHG. KEEP CNTNR
CLSD. USE W/ADEQUATE VENTILATION.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID &/OR SOLID). ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST
BE OBSERVED.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT OF IT IS EXCEEDED,
A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO PERMIT OTHER
NIOSH/MSHA APPRO VED RESPIRATORS UNDER SPECIFIED CNDTNS.
Ventilation:IF PROD IS USED IN CONFINED AREA, PROVIDE SUFFICIENT MECH
(GEN &/OR LOC EXHST) VENT TO MAINTAIN EXPOS BELOW (ING 3)
Protective Gloves:RUBBER, BUTYL/OTHER IMPERVIOUS GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS (ING 4)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . RUBBER SAFETY BOOTS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ:DISCHARGE/OTHER IGNIT SOURCES AT LOCATIONS DIST FROM MATL
HNDLG POINT. FIRST AID PROC:IF PERS IS CONSCIOUS, DILUTE BY GIVING
2 GLASSES OF WATER. CALL MD. KEEP PERS WARM & QUIET. SPILL PROC:T
EMPORARY (OR PERM) DIKE TO CONTAIN SPILL. COLLECT & DESTROY BY LIQ
INCIN. OTHERWISE, DILUTE W/WATER & USING INERT(ING 2)

Boiling Pt:B.P. Text:350F,177C
Vapor Pres:1 @ 63F
Vapor Density:>1
Spec Gravity:>1 (H*2O=1)
Evaporation Rate & Reference:9.03 (N-BUTYL ACETATE=1)
Solubility in Water:0.1%
Appearance and Odor:BLUE PASTE W/SLIGHT SOLVENT ODOR.
Percent Volatiles by Volume:20

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CARBON
DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS. IF
PERMITS & REGULATIONS ALLOW, MAY BE INCINERATED, ALLOWED TO
EVAPORATE OR SOLIDIFIED W/INERT MATERIALS & DISPOSED OF.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.